BRSDB - DEGREASING SOLVENT
- MSDS: BRSDB
- Manufacturer: CALGON VESTAL LABS
- Product Name: DEGREASING SOLVENT
- National Stock Number: 7930-00N042047
Product Identification
Product ID:DEGREASING SOLVENT
MSDS Date:04/25/1989
FSC:7930
NIIN:00N042047
MSDS Number: BRSDB
Responsible Party
ST LOUIS, MO 83110
US
Emergency Phone: 314-535-1810;800-424-9300(CHEMTREC)
Info Phone: 314-535-1810
Preparer: R.C. JANTE
Cage: 0LKT5
Contractor
Telephone: 800-424-9300 (CHEMTREC)
Cage: 0LKT5
Ingredients
STODDARD SOLVENT
CAS: 8052-41-3
RTECS: WJ8925000
Fraction By Weight: 60%
OSHA PEL 500 PPM
ACGIH TLV: 100 PPM; 9293
ETHANE, 1,1,1-TRICHLORO-; (METHYL CHLOROFORM)
CAS: 71-55-6
RTECS: KJ2975000
Fraction By Weight: 40%
OSHA PEL 350 PPM;450 STEL
ACGIH TLV: 350 PPM;450 STEL
EPA Report Quantity: 1000 LBS
DOT Report Quantity: 1000 LBS
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES & SKIN:CAUSES IRRITATION.
MAY DEFAT, DRY & CAUSE SCALEING OF SKIN UPON CONTACT. INHAL:HARMFUL
IF INHALED. MAY CAUSE NAUSEA, VOMITING, COUGHING & RESPIRATORY
IRRITATION. INGEST:ASPIRATION IN TO LUNGS CAN OCCUR RESULTING IN
PNEUMONITITS, PULMONARY EDEMA & HEMORRHAGE. CHRONIC:INHAL OF
STODDARD (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SOLVENT SHOW RESULTS OF HEPATIC AND
HEMTOPOLETIC CHANGES. CHLOROCARBON MATERIAL HAVE
PRODUCED/SENSITIZATION OF THE MYOCARDIUM SIMILAR EFFECT IN HUMANS.
ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT
FOR LIFE-SUSTAINING USED IN HUMANS ACUTELY OR CHRONICALLY EXPOSED
TO CHLOROCARBONS .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
First Aid
First Aid:EYES & SKIN:IN CASE OF CNTCT, IMMED FLUSH EYES W/PLENTY OF
WATER FOR AT LEAST 15 MIN. CALL A MD. FLUSH SKIN W/WATER. WASH
CLOTHING BEFORE REUSE. INHAL:IF INHALED REMOVE TO FRESH AIR. IF NOT
BRTHG GIVE ARTF RESP, PREF MOUTH TO MOUTH. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. CALL A MD. INGEST:IF SWALLOWED;DO NOT
INDUCE VOM. CALL A MD. IMMED. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
Fire Fighting
Flash Point Method:TOC
Flash Point:118F,48C
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE
Fire Fighting Procedures:WEAR NIOSH/MSHA PRESSURE DEMAND-APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT . EXERCISE CAUTION WHEN FIGHTING ANY
CHEMICAL FIRE. RESP PROT IS ESSENTIAL.
Unusual Fire/Explosion Hazard:TOXIC GASES & VAPORS SUCH AS HYDROGEN
CHLORIDE, PHOSGENE & CARBON MONOXIDE MAY BE RELEASED IF INVOLVED IN
FIRE.
Accidental Release
Spill Release Procedures:DIKE AREA, CONTAIN AS MUCH SPILLED MATERIAL
POSSIBLE. REMOVE ANY REMAINING MATERIAL BY ABSORBING ON VERMICULATE
OR OTHER SUITABLE ABSORBING MATERIAL. DISPOSE OF IN APPROVED
LANDFILL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. AVOID BREATHING VAPORS. KEEP CONTAINER CLOSED.
Other Precautions:VAPS ARE HEAVIER THAN AIR AND WILL COLLECT IN LOW
AREAS. USE ONLY IN WELL-VENTILATED AREAS THAT WILL MAINTAIN AIR
LEVELS BELOW LIMITS ESTABLISHED BY FEDERAL, STATE, AND LOCAL
REGULATIONS. NO SMOKING I N AREA OF USE. DO NOT USE IN (SUPP DATA)
Exposure Controls
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IS RECOMMENDED
IF EXCEEDS OSHA TLV'S FOR STODDARD SOLVENT & 1,1,1-TRICHLOROETHANE.
Ventilation:LOCAL AND MECHANICAL EXHAUST IS RECOMMENDED.
Protective Gloves:SOLVENT RESISTANT RUBBER GLOVES.
Eye Protection:CHEMICAL SAFETY GOGGLES .
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
OTHER PREC:THE GENERAL VICINITY OF ARC WELDING, OPEN FLAMES OR HOT
SURFACES. HEAT AND/OR UV RADIATION MAY CAUSE THE FORMATION OF HCL
AND/OR PHOSGENE .
Chemical Properties
HCC:F4
Boiling Pt:B.P. Text:165F,74C
Spec Gravity:0.982 (H*2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID, HYDROCARBON ODOR
Percent Volatiles by Volume:100 WT
Stability
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALUMINUM AND MAGNESIUM POWDERS AND SODIUM AND
POTASSIUM.
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND FLAME.
Hazardous Decomposition Products:HYDROGEN CHLORIDE AND CARBON MONOXIDE
MAY BE RELEASE IF INVOLVED IN A FIRE. PHOSGENE .
Disposal
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.